Product ID:JD-23 JAPAN DRIER, 483-7754 4L-161-1
MSDS Date:10/19/1987
FSC:8010
NIIN:00N018849
MSDS Number: BLGBC

SOUTHERN COATINGS

FULTON STREET
SUMTER, SC 29150
US

Emergency Phone: 803-775-6351

Info Phone: 803-775-6351

Cage: 6M840

SOUTHERN COATINGS

160 SUMTER, SC 29150 US

Telephone: 803-775-6351

Cage: 6M840

2 @ 20C (LIMITS AS STODDARD SOLVENT)

CAS: 64742-88-7

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

ZIRCONIUM

CAS: 7440-67-7

RTECS: ZH7070000

OSHA PEL 5 MG/M3/10 STEL

ACGIH TLV: 5 MG/M3/10 STEL;9192

USE ONLY NON-SPARKING TOOLS. PLACE ABSORB

RTECS: 9999999ZZ

CONTAM OF SEWERS, STREAMS & GROUNDWATER W/SPILLED

RTECS: 9999999ZZ

THIS PROD, IF DISCARDED DIRECTLY, WOULD BE

RTECS: 9999999ZZ

VAPS. IN CONFINED AREAS USE A NIOSH/MSHA APPRVD

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SHORT TERM OVEREXP: INGEST: CAN CAUSE
GI IRRIT, NAUS & VOMIT. ASPIR OF MATL IN LUNGS MAY CAUSE CHEM PNEUM
WHICH CAN BE FATAL. INHAL: MAY CAUSE NOSE/THROAT IRRIT. HIGH CONC
MAY CAUSE ACUTE CNS DEPRESS CHARACT BY HDCH, DIZZ, NAUS & CONFUSN.
EYE: MAY CAUSE IRRIT. SKIN: MAY CAUSE DEFAT & IRRIT. EFTS OF(SEE
EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: RPTD OVEREXP: RPTS HAVE ASSOC PRLNGD
& RPTD OCCUP OVEREXP TO SOLV WITH PERMANENT BRAIN & NERVOUS SYSTEM
DAMAGE. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING CONTENTS MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INGEST:CALL POIS CTL CTR, HOSP EMER ROOM/MD IMMED.
INHAL:REMOVE TO FRESH AIR IMMED. IF BRTHG STOPS, GIVE ARTF RESP.
KEEP WARM & QUIET. CALL MD IMMED. EYES:FLUSH W/LRG AMTS OF WATER,
LIFTING UPPER & LO WER LIDS OCCASNLY. CONTINUE FOR AT LEAST 15 MIN.
CALL MD. SKIN:REMOVE CONTAM CLTHG. WASH AFFECTED AREA W/SOAP &
WATER. CALL MD IF IRRIT PERSISTS. NOTE TO MD:ANY TREATMENT THAT
MIGHT BE (SUPP DATA)

Flash Point:102F,39C
Extinguishing Media:USE NFPA CLASS B FIRE EXTING (CO*2, ALL PURPOSE DRY
CHEM/ALCOHOL FOAM) DESIGNED TO EXTING FLAM LIQ FIRES. (SUPP DATA)
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
WATER MAY BE INEFT, BUT MAY BE USED TO COOL EXPSD CNTNRS TO PVNT
PRESS BUILD-UP & POSS AUTO-IGNIT (SUPP DATA)
Unusual Fire/Explosion Hazard:DURING EMER CNDTNS, OVEREXP TO DECOMP
PRODS MAY CAUSE HLTH HAZ. SYMP MAY NOT BE IMMED APPARENT. CALL MD.
KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM HEAT (SUPP DATA)

Spill Release Procedures:KEEP SPECTATORS AWAY. ELIM ALL IGNIT SOURCES
(FLAMES/HOT SURF/SOURCES OF ELEC, STATIC/FRICTIONAL SPARKS). DIKE &
CONTAIN SPILL W/INERT MATL (E.G. SAND/EARTH). TRANSFER LIQ TO
COVERED METAL CNTNRS FOR RECOVERY/DISP/REMOVE W/INERT ABSORB. (SEE
ING 3)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE ABOVE 95F. STORE LARGE
QTYS IN COMPLIANCE WITH OSHA 29 CFR 1910.106. DO NOT TAKE
INTERNALLY. CLOSE CNTNRS AFTER EACH USE.
Other Precautions:EMPTY CNTNRS MUST NOT BE WASHED & REUSED FOR ANY
PURPOSE. CNTNRS SHOULD BE GROUNDED AND BONDED TO THE RECEIVING
CNTNR. DO NOT WELD, BRAZE OR CUT ON EMPTY CNTNRS. NEVER USE
PRESSURE TO EMPTY. DRUM IS N OT A PRESSURE VESSEL.

Respiratory Protection:SPRAYING OUTDOORS/OPEN/WELL-VEN AREAS, USE
NIOSH/MSHA APPRVD MECH FILTER RESP TO REMOVE OVERSPRAY. RESTRICTED
VENT AREAS, USE NIOSH/MSHA APPRVD PAINT SPRAY (COMBINATION CHEM
CARTRIDGE/MECH FILTER) RES P TO REMOVE SPRAY MIST & ORG (SEE ING 6)
Ventilation:PROVIDE GEN DILUTION & LOC EXHST VENT IN SUFF VOLUME &
PATTERN TO MAINTAIN CONC OF HAZ SUBSTANCES Protective Gloves:SOLVENT IMPERMEABLE GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NOT LIKELY TO BE NEEDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXT MEDIA: POLYMER FOAM IS PREF FOR LRG FIRES. FIRE FIGHT PROC: OR
EXPLO WHEN EXPSD TO EXTREME HEAT. IF WATER IS USED, FOG NOZZ ARE
PREF. EXPLO HAZ: ELEC EQUIP, SPARKS & FLAME. CLOSED CNTNRS MAY
EXPLO DE WHEN EXPSD TO EXTREME HEAT. FIRST AIR PROC: REQ FOR
OVEREXP SHOULD BE DIRECTED AT CONTROL OF SYMP & CLINICAL CNDTNS.

HCC:F4
Boiling Pt:B.P. Text:302F,150C
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:90

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT, SPARKS, FLAMES AND
SOURCES OF IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING/CUTTING, WILL PRODUCE SMOKE, CO & CO*2.

Waste Disposal Methods:DISPOSE I/A/W FED, ST & LOC LAWS. INCIN ONLY IN
EPA PERMITTED FACILITY. DO NOT INCIN CLSD CNTNRS. OBSERVE PREC FOR
DISP OF FLAM MATLS. CONTAMINATED ABSORB MAY BE DISPOSED IN A HAZ
WASTE LANDFILL. DISP OSE ONLY I/A/W FED, ST & LOCAL REGS. (SEE ING
5)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.